Toyota Camry

1996-2001 of release

Repair and car operation


Kamri's Toyota
+ 1. Maintenance instruction
+ 1.2. Information before car driving
+ 1.3. Independent maintenance
+ 1.4. Technical characteristics
+ 1.5. Some councils upon car purchase
+ 2. Maintenance
+ 3. Engines
+ 4. Cooling system
+ 5. Heating and ventilation
+ 6. Fuel system
+ 7. Exhaust system
+ 8. Transmission
+ 9. Running gear
- 10. Brake system
   10.2. Technical characteristics
   10.3. ABS system
   10.4. Blocks of disk brakes
   10.5. Brake support
   10.6. Brake disk
   10.7. Blocks of drum-type brakes
   10.8. Wheel cylinder of brakes
   10.9. Main cylinder of brakes
   10.10. Hoses and hydraulic actuator tubes
   10.11. Air removal from a hydraulic actuator of brakes
   10.12. Vacuum amplifier of brakes
   10.13. Blocks of the parking brake of back disk brakes
   10.14. Parking brake
   10.15. Cables of the parking brake
   10.16. Switch of a signal of braking
   10.17. ABS: natural choice
   10.18. Malfunctions of brake system
+ 11. Body
+ 12. Electric equipment


10. Brake system

10.1. Introduction
GENERAL INFORMATION

Brakes of considered cars are equipped with a double-circuit hydraulic actuator of brakes of lobbies and back wheels. Forward brakes disk, back brakes – disk or drum-type.

Brakes are equipped with system of automatic adjustment of a gap in blocks (with a disk or a drum). In drum-type brakes the system of automatic adjustment works at turning on of the parking brake.

Hydraulic actuator of brakes

Hydraulic actuator of brakes double-circuit (separate on lobbies and back wheels). The nutritious tank of brakes is divided into two sections, on one for each contour. Into hydraulic actuator structure in addition enter the double dosing-out valve providing alignment braking of lobbies and back wheels (it is located on a partition of a motor compartment).

Vacuum amplifier

It is mounted on a partition of a motor compartment and provides increase in effort at a brake pedal at the expense of the depression created in an inlet collector of the engine.

Parking brake

The parking brake has a hummock drive on back wheels, joins the lever (on the Camry and Camry Solara models), or (Avalon model) pedal. The lever settles down on the central floor panel of forward facing of salon, the pedal is mounted on the left mudguard of a body in salon.

Care of brakes

After performance of the repair interfaced to dismantling of brakes check their work, moving on the smooth equal road. When braking the car should not leave aside, braking should be smooth. Brakes are checked by smooth and sharp braking on different speeds of movement, avoiding, however, complete blocking of wheels to exclude a proskalzyvaniye of tires on a paving. Efficiency of braking of considered cars is influenced also by a condition of tires, loading of the car and correctness of adjustment of corners of installation of wheels.